SVW140 Warming Drawer
Manual for Installation, Use and Maintenance
Customer Care Department • The
Group Ltd. • Harby Road • Langar • Nottinghamshire • NG13 9HY
Before Using the Warming Drawer
When using the appliance for the first time, clean it as follows:
•
•
Clean the surface with a damp cloth, then dry.
Preheat the empty drawer for at least 2 hours: turn the temperature knob to the max. position in order to eliminate
any manufacturing residuals (grease, oil or resins) which could cause unpleasant odours during cooking. Air the room.
•
After carrying out this simple operation, the appliance will be ready for first use.
Before using the appliance, remove:
•
Stickers on the front and warming drawer door, except the rating plate;
•
Cardboard protection and protective plastic film from all the aesthetic parts, if present. and from the front panel
controls and other parts of the warming drawer;
•
Any stickers from the accessories if present.
Installation
Important : The warming drawer must be immediately fixed to the
cabinet, complying with the following instructions. Do not install the
combined electrical appliance provided for, before fixing the warming
drawer to the cabinet.
Spacers : fix the drawer as shown opposite.
Note : should it be necessary to align the appliance aesthetically with
other combinations of product, the drip tray at the bottom can be
removed and eliminated by unfastening the two fixing screws.
•
Before connecting the appliance to the power supply, compare the connection data (voltage and frequency) given on
the dataplate with that of the electrical mains.
•
•
•
•
The data must match, otherwise the appliance could become damaged.
In case of doubt, contact a qualified technician.
Make sure the socket can be easily accessed even after the appliance has been fitted.
The warming drawer can only be fitted in combination with other appliances not weighing more than 40 kg and
provided with adequate cooling ventilation. Otherwise, the right to the warranty is invalidated, since correct use cannot
be guaranteed.
•
•
For combined appliance installation comply with the instructions given in the relevant use and installation handbook.
Fitting and installation of this appliance must only be carried out by qualified personnel who guarantee that the
requirements for safe use are met.
Measurements
All measurements are given in mm.
•
1. Temperature knob
2. Luminous ON-OFF switch
3. ON-OFF light
Using Your
Warming Drawer
1
2
The control parts are the temperature knob and
the luminous ON-OFF switch.
With the switch pressed (position 1) the drawer is
on, whereas with the switch released (position 0)
the drawer is off.
3
These parts are visible only when the drawer is
open.
When the drawer is closed, a control light on the
front of the appliance indicates if the drawer is
switched on.
Operation
•
•
•
•
•
Place the dishes in the drawer
Set a temperature
Switch the appliance on; the switch lights up
Close the drawer gently
Switch the appliance off before removing the warmed dishes
Selecting the Temperature
•
•
•
•
The temperature knob enables a temperature adjustment of
between approx. 30°C and 85°C.
Temperature Temperature
Control
Information Regarding Use
Hot drinks in glasses previously warmed at this
temperature do not become cool so quickly,
and in any case the container can be touched
without any risk
Turn the temperature knob all the way clockwise to max. and
then anticlockwise.
approx. 40°C
Cups, Glasses
Do not force it past the stop, otherwise the thermostat will be
damaged.
The food on these plates stays hot for a longer
time. The containers can be touched without
any risk, otherwise use gloves or pot-holders
approx. 60°C
Plates
The temperature scale does not indicate the absolute
temperature values in °C, but gives symbols that represent the
optimum temperature for the respective dish group.
The thermostat is set to max temperature.
The containers can be touched with special
gloves or pot-holders
approx. 85°C
Crockery
Warming Times
dishes for 6 persons
The time necessary for warming dishes, glasses, etc. depends on
various factors:
6
6
1
1
1
2
plates
Ø28cm
Ø10cm
Ø22cm
Ø19cm
Ø17cm
Ø36cm
broth cups
soup plate
soup plate
soup plate
meat plates
•
•
•
•
Material and thickness of the dishes
Load amount
Load arrangement
Temperature setting
or as required
Therefore exact indications cannot be provided.
20
36
30
10
10
10
80
40
30
18
2
plates
Ø26cm
Ø22cm
Ø10cm
Ø27cm
Ø22cm
Ø36cm
soup plates
soup bowls
plates
soup plates
pizza plates
espresso coffee cups
cappuccino cups
glasses (grog)
soup plates
It is advisable to find the required optimum settings by practical
experience.
Load Capacity
•
The load capacity depends on the height of the appliance and
the size of the dishes.
•
•
The following load examples are only a guide.
Remember that the maximum drawer load is 25kg.
Ø22cm
21cmx18cm
meat plates
Care and Cleaning
Important : never clean the appliance with high pressure water or steam cleaning equipment.
Also avoid using : detergents containing soda, acids or chlorides, abrasive detergents (in powder or lotion), abrasive
sponges (e.g. steel wool) or sponges containing residuals of abrasive detergents, descaling detergents, dishwasher
detergents, oven sprays.
Do not use corrosive products, hard sponges or rough cloths for cleaning.
Warming drawer exterior
•
•
Clean with a damp cloth. If it is very dirty, add a few drops of dishwashing detergent to the water. Dry with a dry cloth.
Do not use corrosive or abrasive detergents, as they can create dull areas. If any of these products accidentally comes
into contact with the warming drawer, immediately clean the appliance with a damp cloth.
•
Slight colour differences on the front of the appliance are due to the use of different materials, such as glass, plastic and metal.
Front panel
Use a mild detergent and a soft window cleaning cloth or a microfibre cloth that does not leave fibres on the surface.
Wipe horizontally, without pressing.
•
Antislip drawer base
•
Extract the antislip base to access and clean the bottom of the drawer. Wash the base by hand with hot water and a
mild detergent. Dry it thoroughly. Refit the antislip base in the drawer only when completely dry
Removing the Warming Drawer
•
•
•
•
•
The drawer can be removed in order to clean the inside.
Open the drawer fully (see pic. 1)
Undo the 2 front screws (1 on each side) - (pic. 2)
Lift the 2 hooks (1 on each side) - (pic. 3-4)
Hold the front part of the drawer on both sides, because the rear part of the
side guides has been lubricated.
1
•
•
•
Remove the drawer by carefully lifting it upwards (pic.5) and put it down.
The inside of the appliance can now be cleaned, using water and detergent.
Do not place the drawer in water once it has been removed.
Refitting the Warming Drawer
•
•
•
•
To refit the drawer, carry out the removal procedure in reverse order.
2
3
4
To do this, place the drawer off the guides.
NB : There is a fixing hook on the left and right side under the warming drawer.
The drawer can be opened only if the fixing hook is in the correct position.
hook
hook
drawer
side guide
5
Troubleshooting Guide
If the dishes are not warm enough, make sure :
•
•
•
•
the appliance is on
the right temperature has been set
the heat openings are not covered by large dishes or soup-plates
the dishes have been warmed for a long enough time.
Different factors affect the warming time, e.g :
•
•
the material and thickness of the dishes, the load amount and its arrangement, temperature setting.
optimum dish warming times are subjective, therefore it is advisable to carry out trials to define them according to needs.
Customer Care
Before calling CDA Customer Care :
•
•
Try to solve the problem on your own, according to the points described in “Troubleshooting Guide”.
Switch the appliance off and then on again it to see if the problem has been eliminated.
For the following problems, contact a qualified technician or CDA Customer Care :
•
If the dishes are not warmed, make sure:
- the main power switch is on;
- the power cable is not disconnected or damaged.
•
•
If the dishes become too hot:
- the temperature controller may be faulty.
The On/Off switch does not light up when the appliance is switched on:
- the switch control light is faulty.
If the fault persists after the above checks, contact CDA Customer Care.
Always specify:
•
•
•
•
•
a brief description of the fault;
the type and exact model of the warming drawer;
the Service number (number after the word Service on the rating plate), located on the outer right edge of the drawer slide.
your full address;
your telephone number.
If any repairs are required, contact CDA Customer Care (to guarantee the use of original spare parts and correct repair).
Failure to comply with these instructions may compromise the safety and quality of the product.
DECLARATION OF CONFORMITY
•
•
•
This drawer is suitable to come into contact with food products and complies with European Regulation (CE) No.
1935/2004.
This appliance is designed for use only as an appliance for warming or keeping cooked food or dishes warm. Any other
use (for example for room heating) is considered improper and therefore potentially dangerous.
This appliance has been designed, manufactured and marketed in compliance with:
- safety objectives of the “Low Voltage” Directive 2006/95/EC (which replaces 73/23/EEC and subsequent amendments;
- The protection requirements of EMC Directive 89/336/EEC;
- the requirements of Directive 93/68/EEC.
Important
•
This appliance is not to be used by persons (including children) with limited physical, sensorial or mental capacities
or with insufficient knowledge or experience, unless they are under supervision or have been instructed in advance
on how to use the appliance by those responsible for their safety.
•
•
•
•
•
•
The warming drawer must not be used by young children or the infirm without supervision.
Make sure children do not play with the appliance.
The accessible parts of the warming drawer may become hot during use; keep children away from the appliance.
Do not use abrasive materials or substances to clean the glass as they may damage it.
The appliance becomes very hot during use. Be careful not to touch the heating elements inside the warming drawer.
The warming drawer is only intended for domestic use, for heating dishes. Other uses are not allowed.
The Manufacturer declines any liability for improper use or incorrect setting of the controls.
•
•
•
•
•
•
•
•
•
Any repairs or adjustments must be carried out exclusively by a qualified technician.
Make sure the appliance is securely fixed to the cabinet with the special screws supplied.
Do not expose the warming drawer to the atmospheric agents.
Do not rest or sit on the drawer when open, as this will damage the telescopic slides.
The max. capacity of the drawer is 25Kg.
Do not cover the bottom of the warming drawer with aluminium foil or other objects.
The drawer seals must be kept clean to ensure that it closes properly.
Never pour water directly in warming drawer.
The juices of fruit dripping from the pan may leave permanent stains. It is advisable to clean the warming drawer
before reusing it.
•
•
•
To avoid scratching, do not drag dishes on the bottom of the warming drawer.
Use suitable containers or crockery.
Residual condensation could eventually damage the warming drawer and surrounding cabinets. It is advisable to:
- cover food;
- dry the wet parts when the warming drawers cold.
•
•
•
Do not touch the warming drawer with wet parts of the body or use it when barefoot.
Do not pull the appliance or the power cable to unplug it.
Do not allow children to touch:
- the controls and the warming drawer in general, especially during use and immediately afterwards, to avoid injury;
- packing materials (bags, polystyrene, metal parts, etc.);
•
•
Make sure the electrical cables of other appliances used near the warming drawer do not touch hot parts.
Do not keep plastic or flammable objects in the warming drawer. When operating the appliance these objects could
melt or catch fire.
•
•
•
Use special oven gloves to remove hot dishes.
Pressing the On button switches on the warmer drawer heating; risk of burns.
Never insert objects (e.g. screwdrivers, sharp objects, papers, etc.) in the heating element and fan protection grill openings.
THE MANUFACTURER DECLINES ALL RESPONSIBILITY FOR EVENTUAL DAMAGES CAUSED BY FAILURE TO
OBSERVE THESE INSTRUCTIONS.
Safeguarding the Environment
Disposal of packing material :
•
•
The packing material is 100% recyclable and is marked with the recycle symbol .
The various parts of the packing must be disposed of in compliance with local regulations; do not disperse in the
environment.
Disposal of old electrical appliances :
•
This appliance is marked in compliance with European Directive 2002/96/EC, Waste Electrical and Electronic
Equipment (WEEE).
By ensuring correct disposal of the product, the user can help prevent potentially negative consequences for the
environment and the health of persons.
The symbol
on the product or on the accompanying documentation indicates that it should not be treated as domestic
waste but must be taken to an appropriate collection centre for the recycling of electrical and electronic equipment.
Scrap the appliance in accordance with local regulations on waste disposal.
For further information regarding the treatment, recovery and recycling of this appliance, contact the competent local
office, the domestic waste collection service or the shop where you purchased the product.
Notes :
Notes :
To contact our Customer Care Department, or for Service,
please contact us on the details below.
Customer Care Department • The
Group Ltd. • Harby Road • Langar • Nottinghamshire • NG13 9HY
|